Aerodynamics of a half-rotating wing in hovering flight: An integrated study

Abstract

This study introduces a new quasi-flapping wing driving mechanism based on a half-rotating mechanism which is capable of pure rotational flapping rather than the more traditional oscillatory flapping method. Lift models for half-rotating wing (HRW) aircraft in hovering flight are proposed based on the kinematics of a HRW prototype and the flow characteristics near the surface of its wing. Alongside further analytical expressions for lift based on kinematic extractions, computational models and a novel lift validation mechanism are used to reinforce the aerodynamic characteristics of the HRW in hovering flight. The aerodynamics of the HRW are experimentally assessed for different wing layouts and wing materials. Results indicate that the flow field generated by the motion of the wing arranged symmetrically on both sides of the body interfere with each other, causing the average lift coefficient of the paired-wing HRW to be less than that of the single-wing HRW. The average lift coefficient of the flexible wing is larger than that of the rigid wing. In addition, the average lift of the flexible wing increases with increasing flexural compliance within a particular range. Lift forces in different flight conditions are calculated using derived formulas alongside representative computational models, through which the derivation of lift variation for the HRW in hovering flight is validated. The theoretical lift curves show reasonable agreement with numerical simulation results in terms of the time course over one stroke cycle. The mechanisms of the HRW for generation and shedding of vortices in hovering flight are further revealed in computed flow field characteristics results. The velocity vectors of the flow field between the HRW and the symmetrically rotating wing indicate that the HRW with asymmetric rotation can generate lift force effectively. The velocity difference between the wing and the fluid is the key factor influencing the structure of generated vortices. In detailed three-dimensional (3D) vortex flows, our computational fluid dynamics study shows that a horseshoe-shaped vortex is first generated in the early downstroke. The horseshoe-shaped vortex subsequently grows into a doughnut-shaped vortex ring, with a jet stream appearing in its core which forms the downwash. The doughnut-shaped vortex ring eventually elongates into a long arc-shaped wake vortex ring. A large increasing lift force is generated during the upstroke, most likely due to the stable distal attached vortices; and in accordance with this, downwash becomes evident in the vortex ring during the downstroke.

Keywords

Half-rotating wing hovering flight lift estimation aerodynamic experiment computed flow field characteristics

Get full access to this article

View all access options for this article.

References

Qiu

. Half-rotating mechanism: structure, characteristics and application. Hefei, China: University of Science and Technology of China Press, 2011.

Fearing

Chiang

Dickinson

, et al. Wing transmission for a micromechanical flying insect. In: IEEE international conference on robotics and automation, San Francisco, CA, 24–28 April 2000, 2000.

Smith

MJC

. Simulating moth wing aerodynamics towards the development of flapping-wing technology. AIAA J 1996; 34: 1348–1355.

Yang

Song

, et al. The progress and challenges of aerodynamics in the bionic flapping-wing micro air vehicle. J Exp Fluid Mech 2015; 29(3): 1–10. (in Chinese).

Shyy

Kang

C-K

Chirarattananon

, et al. Aerodynamics, sensing and control of insect-scale flapping-wing flight. Proc Roy SocMath Phys Eng Sci 2016; 472(2186): 20150712.

Faisal

AHM

Filippone

. Aerodynamic model for tandem flapping wings. AIAA J 2016; 54: 3849–3858.

Nakata

Liu

Bomphrey

. A CFD-informed quasi-steady model of flapping-wing aerodynamics. J Fluid Mech 2015; 783: 323–343.

Mayo

Lankford

Benedict

, et al. Aeroelastic analysis of avian-based flexible flapping wings for micro air vehicles. J Am Helicopter Soc 2015; 60: 1–18.

Tay

de Baar

JHS

Percin

, et al. Numerical simulation of a flapping wing MAV based on wing deformation capture analysis. In: 34th AIAA applied aerodynamics conference, Washington, DC, 13–17 June 2015.

10.

Chung

Dorothy

. Neurobiologically inspired control of engineered flapping flight. J Guid Control Dynam 2015; 33: 440–453.

11.

Tay

Deng

van Oudheusden

, et al. Validation of immersed boundary method for the numerical simulation of flapping wing flight. Comput Fluids 2015; 115: 226–242.

12.

Weis-Fogh

. Quick estimates of flight fitness in hovering animals, including novel mechanisms for lift production. J Exp Biol 1973; 59(1): 169–230.

13.

Dickinson

Gotz

. Unsteady aerodynamic performance of model wings at low Reynolds numbers. J Exp Biol 1993; 174(1): 45–64.

14.

Ellington

van den Berg

Willmott

, et al. Leading-edge vortices in insect flight. Nature 1996; 384: 626–630.

15.

Willmott

Ellington

Thomas

ALR

. Flow visualization and unsteady aerodynamics in the flight of the hawkmoth, Manduca sexta. Philos Trans R Soc Lond Ser B: Biol Sci 1997; 352(1351): 303–316.

16.

Sane

. The aerodynamics of insect flight. J Exp Biol 2003; 206(23): 4191–4208.

17.

Dickinson

. Wing rotation and the aerodynamic basis of insect flight. Science 1999; 284(5422): 1954–1960.

18.

Karásek

Muijres

De Wagter

, et al. A tailless aerial robotic flapper reveals that flies use torque coupling in rapid banked turns. Science 2018; 361(6407): 1089–1094.

19.

Wei

Cui

, et al. Inertia force of flapping wing in entomopter micro air vehicle. J Aero Power 2008; 23: 1279–1286. (in Chinese).

20.

Qiu

Wang

. Half-rotating mechanism: a biomimetic mechanism of animal motion and its basic motion characteristics. Mech Sci Technol Aero Eng 2011; 30(4): 600–604. (in Chinese).

21.

Qiu

Wang

Chen

, et al.

Research on simplest design for half rotating mechanism

J Mach Des 2017; 34(10): 75–80. (in Chinese).

22.

Wang

Qiu

, et al. Motion error analysis and structure optimization for driving mechanism of half-rotating wing based on local constraints. Mech Sci Technol Aero Eng 2017; 36(6): 1–7. (in Chinese).

23.

Jang

Cao

Cheng

. Lift and drag coefficients of flow around a flat plate at high attack angles. Chin J Appl Mech 2011; 28(5): 518–520. (in Chinese).

24.

Yang

Shu

, et al. Micro-flapping wing design and test for aerodynamic properties. Mech Sci Technol 2006; 25(1): 12–14. (in Chinese).

25.

Zhang

Zhu

Zhou

. Experiment research on aerodynamics of flexible wing MAV. Acta Aeronaut Astronaut Sin 2008; 29(6): 1440–1446. (in Chinese).

26.

Lee

Cho

, et al. Effect of flexibility on flapping wing characteristics in hover and forward flight. Comput Fluids, 2018; 173: 111–117.

27.

Liu

Ang

, et al. Numerical investigation of flexible flapping wings using computational fluid dynamics/computational structural dynamics method. Proc Inst Mech Eng G: J Aerosp Eng 2018; 232(1): 85–95.

28.

Holman

Brionnaud

Chavez Modena

, et al. Lattice Boltzmann method contribution to the second high lift prediction workshop. J Aircr 2015; 52(4): 1–14.

29.

Ducros

Nicoud

, and Poinsot

. Wall-adapting local eddy-viscosity models for simulations in complex geometries. In: Proceedings of 6th ICFD conference on numerical methods for fluid dynamics, Oxford, 1998, pp. 293–299. ICFD.

30.

Shih

T-H

Povinelli

Liu

N-S

, et al. A generalized wall function, NASA TM-113112, 1999.

31.

Patankar

Spalding

. Heat and mass transfer in boundary layers. J Adv Heat Transfer 1966; 3: 33–100.

32.

Launder

Spalding

. The numerical computation of turbulent flows. Comput Methods Appl Mech Eng 1974; 3(2): 269–289.

33.

Lin

H-T

. The analogy between fluid friction and heat transfer of laminar forced convection on a flat plate. Wärme- und Stoffübertragung 1994; 29(3): 181–184.

34.

Hasan

Emre

. Analysis of Flettner rotor ships in beam waves. J Ocean Eng 2018; 150: 352–362.

35.

Birch

Dickinson

. The influence of wing-wake interactions on the production of aerodynamic forces in flapping flight. J Exp Biol 2003; 206(13): 2257–2272.

36.

Aono

Liang

Liu

. Near- and far-field aerodynamics in insect hovering flight: an integrated computational study. J Exp Biol 2008; 211(2): 239–257.

37.

Wang

. Aircraft Aerodynamics. Beijing, China: Tsinghua University Press, 2013.

38.

Birch

Dickson

Dickinson

. Force production and flow structure of the leading edge vortex on flapping wings at high and low Reynolds numbers. J Exp Biol 2004; 207(7): 1063–1072.

39.

Wang

Qiu

, et al. Flow field characteristics and lift changing mechanism for half-rotating wing in hovering flight. In: IOP conference series materials science and engineering, Birmingham, UK, 13–15 October 2017.

40.

Poelma

Dickson

Dickinson

. Time-resolved reconstruction of the full velocity field around a dynamically-scaled flapping wing. Exp Fluids 2006; 41: 213–225.