Investigation of performance characteristics and water flooding in the cathode flow channel of a polymer electrolyte membrane fuel cell

Abstract

This study was experimentally carried out to investigate the relationship between fuel-cell performance and the water flooding phenomena at the cathode, which is an important research area of water management in the polymer electrolyte membrane fuel cell. A transparent fuel cell was fabricated to observe the water flooding phenomenon in the cathode channel. Images of the flooding phenomena were obtained by digital and high-speed cameras under various operating conditions involving cell temperature, cathode flowrate, humidifying temperature, cathode backpressure, and oxygen concentration. At the same time, performance was measured at the potentiostatic mode. In this study, investigations for the effects of operating parameters on the water flooding phenomenon, as well as water droplet generation and removal in the cathode flow channel were made. As time elapsed, it was seen that small water droplets formed and then grew into larger water droplets, when the flooding phenomena occurred.

It was also observed that when the cell temperature increased the occurrence of flooding phenomena decreased due to evaporation, and performance was significantly improved. The water droplets in the cathode channel were found to be almost zero at high cathode flowrates, and the instances of the flooding phenomenon were decreased by evaporation as the humidified temperature was increased. On account of increasing cathode backpressure, the flooding phenomenon due to high partial pressure was reduced and as compared to air when oxygen was used as an oxidant, the water distribution was increased. Based on this experimental study, it is seen that the flooding phenomenon is closely related to fuel-cell performance.

Keywords

water flooding visualization performance operating conditions

Get full access to this article

View all access options for this article.

References

Bazlak

Liquid water visualization in PEM fuel cells: a review. Int. J. Hydrogen Energ., 2009, 34. 3845–3857.

Owejan

J. P.

Gagliardo

J. J.

Sergi

J. M.

Kandlikar

S. G.

Trabold

T. A.

Water management studies in PEM fuel cells, Part I: Fuel cell design and in situ water distributions. Int. J. Hydrogen Energ., 2009, 34. 3436–3444.

Kandlikar

S. G.

Rath

Grimm

Domigan

White

A. D.

Hardbarger

Owejan

J. P.

Trabold

T. A.

Water management studies in PEM fuel cells, part II: ex situ investigation of flow maldistribution, pressure drop and two-phase flow pattern in gas channels. Int. J. Hydrogen Energ., 2009, 34. 3445–3456.

Tüber

Pócza

Hebling

Visualization of water buildup in the cathode of a transparent PEM fuel cell. J. Power Sources, 2003, 124. 403–414.

Yang

X. G.

Zhang

F. Y.

Lubawy

A. L.

Wang

C. Y.

Visualization of liquid water transport in a PEFC. Electrochem. Solid St., 2004, 7. A408–A411.

H. P.

Zhang

H. M.

Cai

Y. H.

B. L.

Diagnostic tool to detect liquid water removal in the cathode channels of proton exchange membrane fuel cells. J. Power Sources, 2006, 162. 469–473.

Weng

F. B.

Hsu

C. Y.

The study of the effect of gas stoichiometric flow rate on the channel flooding and performance in a transparent fuel cell. Int. J. Hydrogen Energ., 2007, 32. 666–676.

Spernjak

Prasad

A. K.

Advani

S. G.

Experimental investigation of liquid water formation and transport in a transparent single-serpentine PEM fuel cell. J. Power Sources, 2007, 170. 334–344.

Murahashi

Kobayashi

Nishiyama

Combined measurement of PEMFC performance decay and water droplet distribution under low humidity and high CO. J. Power Sources, 2008, 175. 98–105.

10.

Liu

Guo

C. F.

Flow dynamic characteristics in flow field of proton exchange membrane fuel cells. Int. J. Hydrogen Energ., 2008, 33. 1040–1051.

11.

Weng

F. B.

Hsu

C. Y.

Chen

Y. M.

Studies on flooding in PEM fuel cell cathode channels. Int. J. Hydrogen Energ., 2006, 31. 1031–1039.

12.

Liu

Guo

Water flooding and two-phase flow in cathode channels of proton exchange membrane fuel cells. J. Power Sources, 2006, 156. 267–280.

13.

Liu

Guo

Water flooding and pressure drop characteristics in flow channels of proton exchange membrane fuel cells. Electrochim. Acta, 2007, 52. 3607–3614.

14.

Weng

F. B.

Hsu

C. Y.

Lee

C. Y.

Study of water-flooding behavior in cathode channel of a transparent proton-exchange membrane fuel cell. J. Power Sources, 2006, 157. 674–680.

15.

Hottinen

Himanen

Lund

Effect of cathode structure on planar free-breathing PEMFC. J. Power Sources, 2004, 138. 205–210.

16.

Hussaini

I. S.

Wang

C. Y.

Visualization and quantification of cathode channel flooding in PEM fuel cells. J. Power Sources, 2009, 187. 444–451.

17.

Sugiura

Nakata

Yodo

Nishiguchi

Yamauch

Itoh

Evaluation of a cathode gas channel with a water absorption layer/waste channel in a PEFC by using visualization technique. J. Power Sources, 2005, 145. 526–533.

18.

Ous

Arcoumanis

The formation of water droplets in an air-breathing PEMFC. Int. J. Hydrogen Energ., 2009, 34. 3476–3487.

19.

Park

Tran

Abdel-Baset

Hussey

D. S.

Jacobson

D. L.

Arif

Neutron imaging investigation of liquid water distribution in and the performance of a PEM fuel cell. Int. J. Hydrogen Energ., 2008, 33. 3373–3384.

20.

Bedet

Maranzana

Leclerc

Lottin

Moyne

Stemmelen

Mutzenhardt

Canet

Magnetic resonance imaging of water distribution and production in a 6 cm² PEMFC under operation. Int. J. Hydrogen Energ., 2008, 33. 3146–3149.

21.

Yuan

X. Z.

Wang

Blanco

Martin

J. J.

Zhang

Diagnostic tools in PEM fuel cell research: part II physical/chemical methods. Int. J. Hydrogen Energ., 2008, 33. 1747–1757.

22.

Najjari

Khemili

Nasrallah

S. B.

The effects of the cathode flooding on the transient response of a PEM fuel cell. Renew. Energ., 2008, 33. 1824–1831.

23.

Theodorakakos

Ous

Gavaises

Nouri

J. M.

Nikolopoulos

Yanagihara

Dynamic of water droplets detached from porous surfaces of relevance to PEM fuel cells. J. Colloid Interf. Sci., 2006, 300. 673–687.

24.

Masuda

Ito

Oshima

Sasaki

Comparison between numerical simulation and visualization experiment on water behavior in single straight flow channel polymer electrolyte fuel cells. J. Power Sources, 2008, 177. 303–313.